SMOKE SYSTEM KIT MODELS SA200 SERIES from Aircraft Spruce

Worldwide Distributor of Aircraft Parts and Pilot Supplies

Shopping Tools

Airframe Parts - Smoke Systems

SMOKE SYSTEM KIT MODELS SA200 SERIES

BOTH OF THE SA-200 SERIES SMOKE SYSTEM OIL TANKS ARE THE SAME SIZE (DIMENSIONS). MODELS DIFFER BY OIL SUCTION TUBE DESIGN.

SA-200 AND 201
(*shown with optional Remote Switch Kit)

Dimensions	Size
HEIGHT (TO TOP OF FILL CAP)	14"
WIDTH (END WHERE OIL PUMP IS MOUNTED)	10"
DEPTH (PUMP TO OPPOSITE END OF TANK)	17.25"
NOTE: ADD 1.5" AT BASE OF TANK ON SIDES AND ENDS FOR BRACKET WIDTH.

THIS PIC IS OF A TYPICAL YAK 52 SETUP WITH THE OIL TANK INSTALLED BEHIND THE VERTICAL SUPPORT THAT IS LOCATED BEHIND THE REAR SEAT. INSTALLATION ACCESS IS GAINED THROUGH THE COVER UNDER THE REAR MOST WINDOW. THE OIL PUMP WILL BE LOCATED NEAR THE TWO AIR BALLS ON THE RIGHT SIDE OF THE FUSELAGE (YOU ARE LOOKING AT THIS SYSTEM FROM THE FRONT).

FEATURES:

FILL CAP IN CENTER OF OIL TANK FOR EASY FILLING THROUGH ACCESS COVER UNDER REAR MOST WINDOW
SUCTION TUBE CENTER/REAR OF OIL TANK FOR BEST PICKUP

5.5 GALLON SMOKE SYSTEM CAPACITY AND RUN TIME

OIL TANK CAPACITY

SA-200 SERIES KITS

APPROXIMATE GALLONS OF OIL USED PER MINUTE

APPROXIMATE TOTAL RUN TIME AT BEST OIL MIXTURE VALVE SETTING

(turn valve down and add more run time!)

5.5 US GALLONS

7+ MINUTES

5.5 GALLON SMOKE SYSTEM WEIGHT AND BALANCE

OIL TANK EMPTY

Includes mounting brackets and hardware,

oil pump w/bracket, flop tube, vent system etc.

OIL TANK FULL

Includes mounting brackets and hardware, oil pump w/bracket, flop tube, vent system etc.

OIL PUMP

Includes side mount bracket and hardware.

COMPONENTS

Hoses, switches, valve, injector, etc.

(includes Remote Switch Kit)

SA-200 SERIES KITS TOTAL WEIGHT FULL (everything included)

15 POUNDS

56 POUNDS

5 POUNDS

3 POUNDS

59 POUNDS

Note: The weights shown are based on the SA-200 series (inverted flight w/oil pump bracket) single injector, smoke system kit. Weights may vary with addition or subtraction of components.

SA-200

FOR LEVEL AND NON-CONTINUOUS INVERTED, POSITIVE G FLIGHT
ANY DIMENSION TOP
PUMP CAN BE MOUNTED ON TOP OR ANY SIDE
FILL CAP AND OTHER FITTINGS INSTALLED WHERE YOU WANT THEM
ALL HARDWARE INCLUDED FOR COMPLETE INSTALLATION

SA-201

CONTINUOUS INVERTED FLIGHT
ANY DIMENSION TOP
PUMP MOUNTED ON TOP OR ANY SIDE
FILL CAP AND OTHER FITTINGS INSTALLED WHERE YOU WANT THEM
ALL HARDWARE FOR COMPLETE INSTALLATION

SA-201T

Note: Add 1.5" at base of tank on sides and ends for bracket width.

SA-201T SMOKE KIT OIL PUMP
This 5.5 Gallon smoke system kit is for continuous inverted flight with oil pump mounted on the top of the oil tank.

This particular kit has been installed in the baggage area of a CJ6A, T34A and RV7 to date. Use this kit when height is not an issue.

Dimensions:
Height (to top of oil pump) 16-1/4"
Width (left to right) 13"
Depth (end with label) 10"

PN 05-03398
$899.00 ($979.91CAN)

Model	Description	P/N	Price	Buy
SA-200	5.5 GAL. SMOKE SYSTEM KIT FOR NON-CONTINUOUS INVERTED FLIGHT	05-02887	$887.00 ($966.83CAN)
SA-201	5.5 GAL. SMOKE SYSTEM KIT FOR CONTINUOUS INVERTED FLIGHT	05-02891	$899.00 ($979.91CAN)
SA-201T	5.5 GAL. SMOKE SYSTEM KIT FOR NON-CONTINUOUS INVERTED FLIGHT WITH OIL PUMP MOUNTED ON THE TOP OF THE OIL TANK	05-04479	$887.00 ($966.83CAN)
ALL COMPONENTS LESS OIL TANK	THIS KIT CONTAINS VIRTUALLY EVERY PART THAT YOU WILL NEED TO COMPLETE YOUR SMOKE SYSTEM EXCEPT OIL TANK!	05-03366	$598.00 ($651.82CAN)
REMOTE SWITCH KIT	OPERATE SYSTEM FROM CONTROL STICK, YOKE OR THROTTLE	05-01443	$63.50 ($69.22CAN)
SECOND INJECTOR KIT WITH INITIAL ORDER	NOT NECESSARY FOR GOOD SMOKE BUT WILL MAKE THE SMOKE TRAIL A LITTLE MORE DENSE	05-02890	$87.00 ($94.83CAN)
SECOND INJECTOR KIT POST ORDER	NOT NECESSARY FOR GOOD SMOKE BUT WILL MAKE THE SMOKE TRAIL A LITTLE MORE DENSE	05-02892	$98.00 ($106.82CAN)
20/32 VOLT DC TO 13.8 VOLT DC CONVERTER Oil for size comparison only.	* CONVERT 20 TO 32 VOLT DC TO 13.8 VOLT DC * PRE-WIRED AND LABELED WITH EASY TO FOLLOW INSTRUCTIONS FOR QUICK INSTALL * COMPACT SIZE * USE TO POWER OTHER 12 VOLT ACCESSORIES LENGTH = 5 1/2", WIDTH = 4 1/2", HEIGHT = 3"	05-02893	$175.95 ($191.79CAN)
BATTERY SPLITTER HARNESS	FOR 24 VOLT SYSTEMS THAT HAVE TWO (2) 12 VOLT BATTERIES LINKED TOGETHER TO MAKE 24 VOLTS	05-02894	$35.00 ($38.15CAN)
EXTERNAL FILL KIT Click image to enlarge	THIS KIT HAS EVERYTHING RIGHT DOWN TO THE VINYL LETTER TRANSFER "SMOKE OIL ONLY" AND DETAILED INSTALLATION INSTRUCTIONS	05-03595	$99.85 ($108.84CAN)

Order Status • Cart/Checkout • Search • Home • Help • Contact Us
ACS Specials/New Products • Shopping Lists • Price Match • Sitemap

Exchange rates as of Nov 13, 2009 are estimates only. Invoice will be in US Dollars.

Copyright © 1995 - 2009 Aircraft Spruce and Specialty Co. All rights reserved. Prices shown are in USD.
Prices, features, and specifications are subject to change without notice.
Images are for reference only and actual product appearance may vary.